As a new FT owner and 1st time RVer is it ok to move the retarder joy stick while driving? Say, if you need to make a panic stop can the joy stick be pulled all the way back while hitting the brakes hard? Also, does the retarder need to be off while using cruise control? I thought I would ask before trying it.
Old Hippie
2002 3610 U320
Retarder should always be on EXCEPT when in very rainy or slippery conditions. (In wet/slippery conditions, the use of heavy braking in conjunction with retarder can cause the rear tires to slide - if that happens the heavy end (with the motor and transmission will try to go first down the road, not a fun sequence)
Retarder comes on automatically when you step on brake, - i think it has 6 levels, and as you push harder on brake, the retarder level increases
Retarder can also be used independently of the brake using the joystick, or you can add more retard with light braking if you like that combination (useful in mountains, keep an eye on transmission temps)
Retarder switch should be in the on position and cruise can be used. Retarder joystick should be in the "off" position (o setting, or full forward) when using the cruise.
Retarder can by itself stop the coach (was a salesman's demo to me)
Each day before you move coach, especially if it has been sitting, push down HARD on brake pedal, to exercise brakes, retarder so effective breaks sometimes get sticky from lack of use
Others may disagree or have more tips.
Have fun!
Like most things foretravel (including aqua hot) once you get used to a retarder, you don't want to go back.
I never drive with the retarder on and never use it on slippery roads. I feel that the brakes work great ,are anti lock ,and by not using the retarder all the time the slack adjusters on the brakes and the brakes them self's are exercised with normal driving. On a down hill I use the joystick to control the retarders and try not to use the brakes to keep them from over heating.You will love to drive a down using the joystick. Even the brake lights work when using the joystick. Watch the transmission temp .Watch the brake lights of the RV's in front of you and you know what a hard time there having. I do exercise the brakes before using the coach for the day. But not with the parking brake on as that can over load the rear brakes,and with only normal pressure on the brake peddle.As said before there are different ways to drive with and use the retarder system .Gam
Change that first line from "never on" to "not engaged" . I do drive with the master switch for the retarder on but with the joystick off.Gam
I run with the Retarder "ON" for braking only when in busy traffic or on a busy freeway.
I find the Retarder brakes too hard for non-busy driving because I coast up to red lights and use light braking for a long distance.
When I bought my coach, three years ago tomorrow, the brake rotors were glazed and the pads were 80% - 90%. Inspector told me to do some hard braking to remove the glaze and increase the effectiveness of the brakes. I believe the glazing and almost no wear on the brake pads at 90,000 miles was from over use of the Retarder.
I do find using the joystick Retarder very usefull when descending hills.
I only switch the retarder off when driving in slippery conditions.
I push the joystick all the way forward for most freeway driving and half way back in city or stop and conditions.
Any time I need braking, I first reach for the joystick. Even in a panic stop, I feel this gets the retarder working a little sooner than after being triggered by the foot brake pedal.
I always use the service brakes to finally stop, and give the pedal a few hard pushes before starting in the morning.
What Tom said.... actually, his description is exactly how we operate our retarder as well.
We usually operate with "Retard" switch "on" and joystick in fully forward position. We use the joystick for special situations where we want some braking any time we are not pressing the accelerator. The special situations usually involve driving in mountains or areas with steep hills.
Check your coach to see if the retarder activates the brake lights when engaged with the joystick. It does not on our coach.
Would someone please explain what is an installation of the joystick after manufacture? My understanding is that the joystick is a simple multi-position switch that controls an extra function built as a factory feature on the transmission. I didn't think that adding the retarder capability to an already installed transmission was feasible. Is that right?
Larry,
You are correct.
Larry and Elliot, Several here have installed a Joystick after buying a coach with a retarder that did not have it. I have a 95 with the 3050R and mine is switch operated only, If I wanted to and wanted to spend a few hundred I could add a joystick. I have not seen the need for it and am quite happy with the operation of the retarder as it is.
Gary B
Early retarder installs used pressure switches only on the brake system to apply a 30\60\90% retarder depending on brake application. On some year U270s the retarder joystick was optional. The joystick allows retarder operation with finer control than the pressure switches and independent of brake application.
It does not replace the pressure switch system. It supplements it.
And on downgrades the precise control of retarding you get from the joystick is priceless.
Makes me wonder if there is a way to have the antilock braking system deactivate the retarder.
Tom, Don't know about the newer systems but on my 95 with the 3050R that is exactly what happens, when ABS kicks in retard is kicked out. Found this out when ABS had problems and I dealt with the engineers that designed the system. Know tho that the ABS on the 95 and maybe some others is now obsolete and these parameters may have changed.
Gary B