Skip to main content ↑ ↓
Topic: Airbags (Read 497 times) previous topic - next topic

Airbags

The air bags on our 270 are about at the end of the road. Bad photo but the outer skin is dried out and you can scratch it right off with a fingernail. The number is AY-NIT15L. What's the best/least expensive source for these? I know - I should do a search!
jor

93 225
95 300
97 270
99 320

Re: Airbags

Reply #1 –
I bought all 8 airbags from Michigan Truck Springs they are on line. The best price and free shipping. 504-273-7292.
Irwin Thomas
1998 u295 36"

Re: Airbags

Reply #2 –
Keep in mind...  Air bags "can' look worse than they actually are. 
Have someone without an agenda look at them to verify their condition.

I had a old Evergreen 45' trailer (reefer) with Glide Ride (air bag) suspension and was looking to replace them until I witnessed a 'Bad" air bag.  Pulled it another 4 years without issue.
I have never seen one explode and they start leaking before needing to be replaced. 
Physical damage is 99.9% of the reason to get one replaced.
The rear bags trend to go away sooner than the fronts, due to heat FWIW.  pc

S/W Houston 95" U320C SE/40' 
Build #4778  Cummins M11
Repairs & Covered RV Parking (BAO)
PPL is close..

Re: Airbags

Reply #3 –
You need to fully raise them and check the area on the bottom normally folded in. I looked at one that was good, until raised was leaking air woth exposed cords showing. On a 1997, replacing all would be good insurance. At nearly 20 years they are probably shot and its much easier to source and install on schedule than out on the road somewhere.
95 U300SE
 

Re: Airbags

Reply #4 –
Quote
Keep in mind...  Air bags "can' look worse than they actually are. 
Quote
You need to fully raise them and check the area on the bottom normally folded in.

Yea, I know they can look pretty bad and still maintain structural integrity. These are probably fine but the bottom part normally folded in is going. I can see the underlying belt material. I will likely replace all eight as I prefer the confidence gained (personally) with the new bags. Thanks to you both.

Irwin, I sent you a PM.
jor
93 225
95 300
97 270
99 320