Annual Service Report. (Note Winegard, item f)

February 03, 2018, 05:15:46 pm

Got our annual service and inspection done, you will see we may ask some more than the usual but we try to be preventative in our maintenance. (We know one couple that all they say they do it engine oil change at CW)

a. Lights under passenger side of coach not working. Found: Fuse at rear of coach blown. Done, found that ground lights fuse was being over amped by an unknown non-factory device, tapped into a 20 amp power point circuit and tested OP

(I do not understand, need to go ask details...non-factory device, what/where?)

b. Check main fuel lines. Found: They are Good

c. Convert Engine Oil Drain Plug: Found: Done, part EZ203

d. Neither roof AC works. Found: Reset thermostat. Show customer how to do

e. Engine Block Heater threw breaker. Found: Heating element had internal short. Done. Drained coolant to install. New seals

f. Noise from Roof. Found: The Winegard antenna had defective part. caused the noise. Winegard replaced entire unit.

g. Service air dryer system. Found: Time for this. Dryer kit air desiccant installed

h. Change transmission filter. Found: R&R main filter, tourqued bolts, topped off 1 qt transynd

i. Change hydraulic filter. Found: cleaned reservoir lid and canister, changed filter and o_ring

j. Check all fluid levels. Found: Low and added to windshield, all other ok

k. Change air filter. Found: was needed, changed air filter and cleaned canister, new seal.

l. Check brakes. Found: All brake pads ok, but right front needed little adjustment. Checked slide pins for proper movement, ok.

m. Engine oil and filters. Found: done, 36 qts delo 400 15W40

o. Gen and engine fuel filters. Found: Done

p. Check front hub oil. Found: all levels ok

q. Check coolant protection. Found: Good

r. Full AH service. Found: Done

s. Generator service. Found: air filer still like new, changed others

t. Grease chassis. Found: Done, no problems noted

u. MCD bedroom shade down on one end. Found. Screws pulled out of wood. Done. Reworked the wood frame, reinstalled.

Probably more than most everybody cares, but maybe will help one person new to the motorhome.

Re: Annual Service Report. (Note Winegard, item f)

Reply #1 – February 03, 2018, 05:38:01 pm

Quote from: Michael & Jackie – February 03, 2018, 05:15:46 pm

Got our annual service and inspection done, Probably more than most everybody cares, but maybe will help one person new to the motorhome.

Thanks for posting such a detailed list. Ours is coming up for service, and I'll make note of anything I've forgotten from your list!

Re: Annual Service Report. (Note Winegard, item f)

Reply #2 – February 03, 2018, 05:54:31 pm

Mike,

Excellent.

Off to Eagle Nest this summer?

Re: Annual Service Report. (Note Winegard, item f)

Reply #3 – February 03, 2018, 06:52:13 pm

Hi Brett, we hope so but may change the timing just a little. I do not know if Hay plans that or he and Trudy off to the longer trip he does in some years.

mike

Foretravel Owners' Forum For owners and Fans of Foretravel Motorcoaches September 10, 2025 ...