Skip to main content ↑ ↓
Topic: Power Tech Generator died (Read 775 times) previous topic - next topic

Power Tech Generator died

My generator ran fine for 10 to 15 minutes and suddenly died. Like it ran out of fuel, yet the tank is at 3/4.
T/S ideas?
Thanks, Dick
Dick, '03 U320 40' Tag, 2 slides, Coach #6075
Full Timers
2009 Honda CR-V

Re: Power Tech Generator died

Reply #1 –
Fuel filter?
Fuel pump?
Fuel line (porous - sucking air)?
Low oil level?
Low coolant level?
Broken fan belt?
1993 U280 SE 40' WTBI, Build: 4359
C8.3 300hp, 6-Speed, Exhaust Brake
960 watts on the roof (6 x 160)
Sorento (or BOLT) on a Kar Kaddy SS
"Nature abhors a vacuum"

Re: Power Tech Generator died

Reply #2 –
Did you look at the panel on the generator? Are there any codes lit or flashing?
Tim Fiedler    2025 LTV Unity MBL on Order
2000 Chevy Tracker 2 Door Convertible 4WD Now lifted 4.5"
1985 Citroen 2CV6 Charleston
Murphy Rebel on wheels with 175HP Titan
Cessna P337
1980 48' Westport MY (!/4 Share)

Re: Power Tech Generator died

Reply #3 –
Mine in my 2000 was doing that. Checked oil pressure switch and temp switch. No lights would come on when it shut down. Ended up being the control board that the lights are on. Pretty easy to change out it you can use hand tools and have 500 bucks. Call Jeff in the tech dept at power tech



Keith
The selected media item is not currently available.Keith & Jo
2003 U320T 4025 PBBS Designer series
Build 6203    Cummins 500hp
2000 U320 4010 WTFE / Build 5762 —Sold—
Motorcade #18070   
Pasadena, Texas
2015 Jeep Wrangler Sahara-Sunset Orange pearl coat
Don't argue with a fool, people watching might not be able to tell the difference.

Re: Power Tech Generator died

Reply #4 –
After is cools down see if it will restart.  Could be an over heating problem.  Are there any  LED lights on?

Check that the breaker to the fan is on.

Check that the fan is pushing/pulling air through the radiator.  if not it could be the start capacitor
1998 U320 40'
2005 GMC Yukon
MC# 17609

Re: Power Tech Generator died

Reply #5 –
Check the wires on the control board and make sure they're tight
Forest & Cindy Olivier
1987 log cabin
2011 Roadtrek C210P
no longer 1999 36' U320 build #5522
2013 Rzr 570 & 2018 Ranger XP1000
2006 Lexus GX470
2011 Tahoe LT 4x4
Previous 1998 45' 2 slide Newell, 1993 39' Newell

Re: Power Tech Generator died

Reply #6 –
Quote from: stevec22 –
After is cools down see if it will restart.  Could be an over heating problem.  Are there any  LED lights on?

Check that the breaker to the fan is on.

Check that the fan is pushing/pulling air through the radiator.  if not it could be the start capacitor


Start capacitor was my problem, when mine died.
Dennis & Martha Harrell
2000 Foretravel U320
2014 GMC 4X4 Sierra Crew Cab Pickup

Re: Power Tech Generator died

Reply #7 –
Oil pressure sensor on my previous coach (not a FT).
Dan - Full timing since 2009
2003 U320 40' Tag 2 slide

Re: Power Tech Generator died

Reply #8 –
You guys are great. That's a good list for me to go after.
Dick
Dick, '03 U320 40' Tag, 2 slides, Coach #6075
Full Timers
2009 Honda CR-V

Re: Power Tech Generator died

Reply #9 –
Another thing that could cause the generator to shut down when everything else checks out is the run/stop solenoid.  This opens the fuel flow when the generator is running and shuts off the fuel flow when you press the stop switch.  It should be located on the fuel rack and have a wire or set of wires going to it.  When power is applied it opens the fuel supply, when power is taken off it closes the fuel supply. 
Forest & Cindy Olivier
1987 log cabin
2011 Roadtrek C210P
no longer 1999 36' U320 build #5522
2013 Rzr 570 & 2018 Ranger XP1000
2006 Lexus GX470
2011 Tahoe LT 4x4
Previous 1998 45' 2 slide Newell, 1993 39' Newell

Re: Power Tech Generator died

Reply #10 –
The relays in control box have been a cure too. They are cheap $2 each and easy to get. I talked to Jeff about oil pressure sensor and he said it would not cause problem.
I would get those relays and replace them, which is what I did a few weeks ago. They are cheap and if not caused by any item mentioned in  Chucks post suggest you try them.
Search postings for relays etc for genetic
Johnh
Coachless, now use aircraft. 2003 Ford Travelair TC280 class C. Super shape. Just for 1 yr .
1994 Ford E350 ClassC,total renovation inside and out. Now sold.
2000 U295  36' Cummins 350 c/w Banks Stinger, Resonator upgrade,Solar, LED lites.Residential fridge with slide out pantry. Build 5674. Sold
ex 92 GV 022C ored Cummins. Sold
ex 95 GV240 cat 3116. Sold
2017 Mini cooper s & 2016 land Rover LR2 HSE  LUX.
jhaygarth@aol.com    SKP #130098
treat everyone as you would like to be.
 

Re: Power Tech Generator died

Reply #11 –
Quote from: John Haygarth –
The relays in control box have been a cure too. They are cheap $2 each and easy to get. I talked to Jeff about oil pressure sensor and he said it would not cause problem.
I would get those relays and replace them, which is what I did a few weeks ago. They are cheap and if not caused by any item mentioned in  Chucks post suggest you try them.
Search postings for relays etc for genetic
Johnh
Lot of (5) NEW Song Chuan 871-1C-C-R1 Mini Relay SPDT 5-prong 12V 20/35A...
$22 dollars delivered
Scott