Skip to main content ↑ ↓
Topic: Water Heater works on electric but not gas (Read 308 times) previous topic - next topic

Water Heater works on electric but not gas

Somewhere along this trip the gas side of our water heater stopped working. Electric works fine. Ideas?
Randy (N4TDT) and Karen Crete
Sarasota, Florida
SOLD:  2000 U270 34' WTFE Build 5756 "Ole Red"

Re: Water Heater works on electric but not gas

Reply #1 –
Flame sensor (Thermal Link)?
Frank & Connie Williams
1999 U320 '36
Build: 5466
MC: 18335

Re: Water Heater works on electric but not gas

Reply #2 –
How far into the "working on gas" does it get?

Ignitor clicks
Gas valve opens
Flame, but goes out
Brett Wolfe
EX: 1993 U240
Moderator, ForeForum 2001-
Moderator Diesel RV Club 2002-
Moderator, FMCA Forum 2009-2020
Chairman FMCA Technical Advisory Committee 2011-2020

Re: Water Heater works on electric but not gas

Reply #3 –

Responding to this type question, I used to always say "Read the trouble shooting steps in the manual".  I still think this is good advice.  If you don't have the manual in your coach owner books, you can find them online.  In the one linked below, scroll down to page 15 to find the section on the DSI models.

https://myrvworks.com/wp-content/uploads/2019/04/Atwood-Water-Heater-Service-Manual.pdf

But these days, when I have a problem with practically anything, first thing I do is go to YouTube and look for a video.  Almost always find something helpful.  The one linked below gives a pretty good sequence of steps to check the 12V power flow.  It mentions the thermal cutoff fuse.  That thing went bad on our heater one time.  Replaced it and we were back in business.  Photo below shows the location on our water heater.

Amazon.com: RV Water Heater Thermal Cut Off Kit Replacement for Atwood...

One other thing - if you decide you need a new circuit board, I recommend you get the one from Dinosaur.  Excellent quality!  Call them and ask if unsure which one you need.

Ignitor Board Index page

https://www.youtube.com/watch?v=IyJWLmlnQ4I

As an Amazon Associate Foretravel Owners' Forum earns from qualifying purchases.
1993 U280 SE 40' WTBI, Build: 4359
C8.3 300hp, 6-Speed, Exhaust Brake
960 watts on the roof (6 x 160)
Sorento (or BOLT) on a Kar Kaddy SS
"Nature abhors a vacuum"

Re: Water Heater works on electric but not gas

Reply #4 –
To close out the thread, when I finally got somewhere to trouble shoot I found no spark and good gas. Using the multimeter I confirmed bad board. Unfortunately we weren't somewhere long enough to order the board and have it delivered so I simply wrote the check to an RV repair facility and that solved the problem. I do plan to order a spare board to have as this is the second board in the five years we've owned the coach that I've had to replace. Thanks to all who responded. Perfect advice.
Randy (N4TDT) and Karen Crete
Sarasota, Florida
SOLD:  2000 U270 34' WTFE Build 5756 "Ole Red"

Re: Water Heater works on electric but not gas

Reply #5 –
Now, IIRC if you don't need your propane heater, you can use the control board in the Hot Water heater, it will just have a time delay before it starts.
Bruce, Linda, and Macy
Zoey RIP 1/20/19
1999 U295 40' build #5400
2017 silver Jeep Wrangler, 1260 watts of solar on top
Moving around the country
 

Re: Water Heater works on electric but not gas

Reply #6 –
Propane water heater: In an emergency on some models, 12 volts through temp sensors to gas valve will start gas flow, which can be lit with lighter.

If gas flame blows out, gas will not shut off.

When tank temp reaches set point, flame will go out, but a later auto restart when temp reduces below set point gas will flow without flame.

It works, just monitor it, then shut if off. You have a hot tank for showers. No reason for cold showers out at a campsite. Fix it when you get home. . .