Skip to main content ↑ ↓
Topic: Aquahot Service Tip (Read 605 times) previous topic - next topic

Aquahot Service Tip

In the little over a year that I've owned our Foretravel, I've had the Aquahot burner assembly out three times (new nozzle, new fuel solenoid, new fuel pump).

With the Aquahot access panel in the small passthrough bay, installing the assembly is the worst part.

I've found the following process to be the best:
1. Lay on your right side.
2. Back the j-bolt nuts off nearly to the end.
3. Place the burner in place and secure it with an allen wrench through the rear flange*.  Just drop it through the holes.
4. Connect the front j-bolt (10mm).  Don't over-tighten.
5. Connect the rear j-bolt.  Don't over-tighten.

* The burner unit and the bigger assembly both have two two-hole flanges that don't seem to be in use.  It looks like it might have been a hinge or something.  Dropping an allen wrench through the holes secures the burner in place while you juggle the opposing j-bolt.  My problem in the past has been that fixing one j-bolt pops the other side loose.
Rick and Donna
1997 U320 4000 WTBI Build 5152 "Molesley"

Re: Aquahot Service Tip

Reply #1 –
On the note of making the process easier, I went out to wally world and purchase a thick quilted blanket in the auto section.  I use it to lay on and drape over the rail of the pull out drawer.  Helps my back and arms while reaching in to the cave!
Joe & Dottie Allen
Sold!  December 2023.      2000 U320; build # 5645
Our coach " Maxine"
Motorcade #  15922;  Escapee 150950; FMCA F330833; Boondockers Welcome;  Harvest Hosts;  Thousand Trails
'98 U320 from 2000-'06
USAF '62-'66

"Do not spoil what you have by desiring what you have not; remember that what you now have was once among the things you only hoped for." ―Epicurus

Re: Aquahot Service Tip

Reply #2 –
I have a couple roll-up foam camping pads I lay on.  One of them is rolled up to support my chest up a bit to relieve the pressure on my bad back the other I lay on.
I'll have to remember the Allen wrench trick, nice!. 
Forest & Cindy Olivier
1987 log cabin
2011 Roadtrek C210P
no longer 1999 36' U320 build #5522
2013 Rzr 570 & 2018 Ranger XP1000
2006 Lexus GX470
2011 Tahoe LT 4x4
Previous 1998 45' 2 slide Newell, 1993 39' Newell

Re: Aquahot Service Tip

Reply #3 –

Susan got me a set of these 3/8" thick interlocking foam mats. Six pieces fit together in many ways.  The surface is smooth enought to make it easy to slide around on.  They sure make crawling into the bay to do an AH service or anything else in the cave.

Amazon.com : Sorbus Interlocking Floor Mat Print, Wood Grain - Light...

As an Amazon Associate Foretravel Owners' Forum earns from qualifying purchases.
Roger Engdahl and Susan Green
2001 U320 3610 #5879 (Home2) - 2014 Jeep Cherokee or 2018 F150
Hastings, MN

Re: Aquahot Service Tip

Reply #4 –
I added electrical disconnects on the thermostat wires and the wire that goes to the bay thermostat. Used a 4 prong for the thermostats and a single for the rear wire. Thinking next service fuel line disconnects.
1999 40 ft. U-320 wtfe build 5563 Chuck & Lynda's "Rollin' Inn"  2030 watts solar
prev. mh's 71 GMC 5 yrs. 73 Pace Setter 1 yr. 78 Vogue 5 yrs 81 FTX 40ft all electric 18 yrs. 1996 Monaco Signature 3 yrs.
2014 Grand Cherokee Overland
Dream as if you will live forever. Live as if you will die today.  James Dean

Re: Aquahot Service Tip

Reply #5 –
Quote from: craneman –
I added electrical disconnects on the thermostat wires and the wire that goes to the bay thermostat. Used a 4 prong for the thermostats and a single for the rear wire. Thinking next service fuel line disconnects.

Great idea, can you share photos?
Joe & Dottie Allen
Sold!  December 2023.      2000 U320; build # 5645
Our coach " Maxine"
Motorcade #  15922;  Escapee 150950; FMCA F330833; Boondockers Welcome;  Harvest Hosts;  Thousand Trails
'98 U320 from 2000-'06
USAF '62-'66

"Do not spoil what you have by desiring what you have not; remember that what you now have was once among the things you only hoped for." ―Epicurus
 

Re: Aquahot Service Tip

Reply #6 –
Quote from: juicesqueezer –
Great idea, can you share photos?
I'll try to find them I posted when I added the electrical.

Found them

Aqua Hot plug addition
1999 40 ft. U-320 wtfe build 5563 Chuck & Lynda's "Rollin' Inn"  2030 watts solar
prev. mh's 71 GMC 5 yrs. 73 Pace Setter 1 yr. 78 Vogue 5 yrs 81 FTX 40ft all electric 18 yrs. 1996 Monaco Signature 3 yrs.
2014 Grand Cherokee Overland
Dream as if you will live forever. Live as if you will die today.  James Dean